No.169, Science (Kexue) Avenue,National HI-TECH Industry Development Zone, Zhengzhou, China [email protected] 0086-371-86549132

ONLINE MESSAGE
MOBILE CEUCHERS

recovery copper flotation recovery copper following:

Development of copper recovery process from flotation ...

2018-6-15 · The aim of this research was to develop a copper recovery process from flotation tailings for an effective utilization of secondary copper resources by a combination method of flotation–HPL–solvent extraction. The most obvious findings to emerge from this study are concluded as follows: (1) High–pressure leaching process (2)

The recovery of copper, by flotation, from calcium-ferrite ...

2004-4-1 · Flotation has been identified as the most economical option to recover the copper from direct copper converting slags (Somerville et al., 2000) where it has been estimated that a copper recovery from the slag of above 90% is required to make the overall single-stage copper

RECOVERY OF COPPER FROM OXIDE COPPER ORE BY

2014-12-24 · RECOVERY OF COPPER FROM OXIDE COPPER ORE BY FLOTATION AND LEACHING Kiraz, Emirhan M.S., Department of Mining Engineering Supervisor: Prof. Dr. Mustafa Ümit Atalay December 2014, 65 pages The aim of this study was the recovery of copper from the oxide copper ore by froth flotation and agitating sulphuric acid (H 2 SO 4) leaching.

Recovery of Copper from Ammoniacal Leachates by Ion

2021-4-27 · Copper and zinc extraction by ammoniacal leaching from microwave-roasted Cu-Zn-Pb sulfidic tailings followed by recovery of copper and zinc by ion flotation and precipitation. Sulfidic copper–lead–zinc tailings can pose a significant environmental threat, ranging from generation of acid mine drainage (AMD) to dam fail

Enhancing the flotation recovery of copper minerals in ...

2020-1-1 · The cumulative copper recoveries increased markedly to over 90%, which represents a significant improvement in comparison to the recoveries obtained from the mill-float process. Sodium alkyl dithiophosphate, mercaptobenzothiazole (FC7245) was found to be the secondary flotation reagent that gave the best copper recoveries.

Copper Flotation - Mineral Processing & Metallurgy

2016-5-16 · In normal practice a recovery of over 90% of the copper which is present as a sulphide is generally possible, whatever the flotation process or circuit employed. As regards the average grade of concentrate, no more can be said than that it depends on the class of the copper-bearing minerals present and their mode of occurrence and on the character of the gangue.

A New Technique for Recovering Copper From Complex

The flotation concentrates can be qualified with a copper grade of 29.37% and a recovery rate of 32.22%. Flotation tailings separated by high-gradient magnetic separation can yield two products,...

Improving copper flotation recovery from a refractory ...

2011-7-1 · Lime is commonly used as a pH regulator and depressant against iron minerals during the flotation recovery of copper minerals from copper porphyry sulfide ore. It can also depress copper oxide, secondary copper sulfide or gold minerals ( Allan and Woodcock, 2001 , Sun, 2001 , Liu et al., 2008a ).

Recovery of Copper from Cyanidation Tailing by Flotation ...

2015-12-10 · Effect of Copper Sulfate on Copper Recovery in the Flotation Process. The effect of copper sulfate on copper recovery were studied at pH 9.8–10.2, xanthate concentration 6.66 × 10 −5 mol/L as collector and 2# oil concentration 10 mg/L as frother. The activation time was fixed at 3 min.

A New Collector for Effectively Increasing Recovery in ...

2019-9-29 · A New Collector for E ectively Increasing Recovery in Copper Oxide Ore-Staged Flotation Renfeng Zhu *, Guohua Gu, Zhixiang Chen, Yanhong Wang and Siyu Song School of Minerals Processing and Bio-Engineering, Central South University, Changsha 410083, China;

Copper Recovery from Silicate-Containing Low-Grade

The recovery of copper reached 93.1% and the grade of copper improved to 18.2 mass% from 0.4 mass% under collector-less opti-mum flotation conditions. The enrichment ratio of copper in the concentrate was 45. The copper concentrate obtained from flotation of the low-grade copper ore was treated by atmospheric leaching

RECOVERY OF COPPER FROM OXIDE COPPER ORE BY

2014-12-24 · RECOVERY OF COPPER FROM OXIDE COPPER ORE BY FLOTATION AND LEACHING Kiraz, Emirhan M.S., Department of Mining Engineering Supervisor: Prof. Dr. Mustafa Ümit Atalay December 2014, 65 pages The aim of this study was the recovery of copper from the oxide copper ore by froth flotation and agitating sulphuric acid (H 2 SO 4) leaching.

Recovery of carbonate copper ore by means of flotation

2020-10-28 · Richert, George Leo, "Recovery of carbonate copper ore by means of flotation at the Kennecott Copper Corporation plant, Kennecott, Alaska" (1926). Professional Degree Theses. 207.

Recovery of copper and cobalt in the comparative

2020-4-16 · flotation tests in order to recovery copper and cobalt. This paper investigates the effect of potassium amyl xanthate (PAX) and sodium dibutyl dithiophosphate (DANA) performance on both copper and cobalt recovery in single roughing flotation. The effect of pH on the flotation is proposed. Some parameters were

Copper Flotation - Mineral Processing & Metallurgy

2016-5-16 · In normal practice a recovery of over 90% of the copper which is present as a sulphide is generally possible, whatever the flotation process or circuit employed. As regards the average grade of concentrate, no more can be said than that it depends on the class of the copper

Improving copper flotation recovery from a refractory ...

Abstract In this paper, N-propyl-N-ethoxycarbonyl thiourea (PECTU) collector was investigated to concentrate copper minerals from a refractory copper porphyry ore through bench-scale and industrial flotation tests. The flotation results indicated that PECTU had strongly collecting power for copper sulfide minerals and excellent selectivity against iron sulfide minerals under moderately ...

Investigation of flotation parameters for copper recovery ...

The results showed an optimum flotation condition at dosages of 80 g/t, 30g/t, and 150 g/t of collector, frother, and dispersant respectively: with copper recovery of more than 60% and a grade of 8%.

Kinetics and Recovery of Xanthate-Copper Compounds

2019-9-30 · The recovery of copper in aqueous media by ion flotation in a laboratory flotation cell was carried out. Hydrodynamics and gas dispersion parameters were obtained. The results show that the increase of potassium amyl xanthate concentration above the stoi-chiometric amount considerably affects the efficiency of the separa-tion of copper.

RECOVERY OF COPPER FROM SMELTING SLAG BY

2015-11-11 · Copper Smelter, Serbia, is currently processed by flotation at the nearby Bor Copper Concentrator. The copper recovery was rather low (about 40%) mainly due to the presence of oxide copper and insufficient mineral liberation. In our previous work, we investigated the technical feasibility of increasing copper recovery by leaching and flotation ...

Copper Sulfide Flotation - Mineral Processing & Metallurgy

2016-4-13 · Flowsheet for treatment of Copper Sulfide ores rich inminerals such as chalcopyrite with gold and silver as well as arsenopyrite. The above flowsheet is designed for the treatment by flotation of copper as chalcopyrite with gold and silver values. The ore, ranging from 60-65% silica, with pyrite, arsenopyrite, and calcite with 3 to 4% copper.

Recovery of carbonate copper ore by means of flotation

2020-10-28 · Richert, George Leo, "Recovery of carbonate copper ore by means of flotation at the Kennecott Copper Corporation plant, Kennecott, Alaska" (1926). Professional Degree Theses. 207.

Recovery of Copper from Flotation Tailings by Leaching ...

A technology route of Reverse flotation of acid-consuming gangue mineralsAcid leaching for copperExtractingElectrodepositing is proposed for recovery copper from a ...

Improving copper flotation recovery from a refractory ...

Abstract In this paper, N-propyl-N-ethoxycarbonyl thiourea (PECTU) collector was investigated to concentrate copper minerals from a refractory copper porphyry ore through bench-scale and industrial flotation tests. The flotation results indicated that PECTU had strongly collecting power for copper sulfide minerals and excellent selectivity against iron sulfide minerals under moderately ...

Study of Flotation Parameters for Copper Recovery from ...

2020-4-1 · flotation, obtaining conditional copper and zinc concentrates. Despite several of studies that have been done related to this issue, effective selective flotation of tennantite ores is still the subject to investigation. 4.2. Effect of particle size distribution on copper recovery Chalcopyrite and tennantite ore samples were received from

Investigation of flotation parameters for copper recovery ...

The results showed an optimum flotation condition at dosages of 80 g/t, 30g/t, and 150 g/t of collector, frother, and dispersant respectively: with copper recovery of more than 60% and a grade of 8%.

An Experimental Investigation on the Copper Recovery

2018-4-2 · In this study, the possibility of copper recovery from flotation tailing of Mazraeh copper mine was investigated. Magnetic separation method was used for concentration of non-magnetic minerals, especially copper bearing minerals, from iron minerals. As a result, copper grade increased up to 0.18% and its recovery reached 86%. Due to mineral’s oxidized surface, accompanied oxide minerals and ...

Development of a Combined Flotation and High Pressure ...

The present study focused on the re-processing of copper and nickel from mine tailings. In this work, recovery of copper and nickel from mine tailing by combined process of flotation and high pressure oxidative leaching were considered. In the first stage, effects of flotation parameters including collector type, collector dosage, and pH and pulp density were examined.

A New Collector for Effectively Increasing Recovery in ...

A new method, staged flotation for effectively increasing the recovery of ultra-fine copper oxide ore with a new type of collector (ZH-1, C3-5 carbon chain xanthate) is proposed for the first time. The flotation process and mechanism were examined by flotation tests,

RECOVERY OF COPPER FROM SMELTING SLAG BY

2015-11-11 · Copper Smelter, Serbia, is currently processed by flotation at the nearby Bor Copper Concentrator. The copper recovery was rather low (about 40%) mainly due to the presence of oxide copper and insufficient mineral liberation. In our previous work, we investigated the technical feasibility of increasing copper recovery by leaching and flotation ...

Recovery of Copper from the Slag of Khatoonabad Flash ...

2013-6-5 · Effect of Particle Size on Copper Recovery. The amount of grinding required to achieve the desired metallurgical results depends on the size of copper minerals forming the slag. To investigate this effect on copper recovery, flotation tests were conducted on the

<< Previous:Concentration Plant Industrial
>> Next:Cone Crusher Agregate Size Adjustment

QUALITY SERVICE

Pre-sale service

Shuttle bus

Factory visit

Business tourism

Conference reception

Sale service

On-the-spot investigation

Conceptual design

Detailed quotation

Sign a contract

After-sale service

Packaging delivery

Installation and debugging

Operation training

Regular visit

1.Liming Heavy Industry, a professional manufacturer, can provide perfect quality assurance system for the products.
2.The flexible payment method can help you relieve project stress.
3.Short stocking period and quick delivery speed can reduce project preparation cycle.
4.There are many transportation ways including sea transportation, air transportation, land transportation, which can make your product reach destination quickly.
5.There is a quick response to your problem. And technicians will provide professional assistance at any time.

Copyright © 2004-2015 by China Liming Heavy Industry Science and Technology Co. LTD All rights reserved Industry News Products